But you don't have to pay … Not too tight would be the rule. Ford Explorer Spark Plug Replacement at your home or office. SPARK PLUGS MUST ONLY BE REMOVED WITH HAND TOOLS. Autolite - For spark plugs with a gasket: 1/4 turn on 10mm plugs, 3/8 turn on 12mm plugs, 1/2 turn on 14mm and 18mm plugs. Torque spec. Spark Plug / Coil-On-Plug Boot. Explorer starting to act up again. My vhicle is a '99 Ford Explorer Limited AWD 5.0 with about 107,000 miles on her. Spark plug is inserted at an angle during installation: Excessive tightening torque: Spark plug wrench slipped or used at an angle: Do not use the wrench at first. Spark Plugs are what gets your engine going and what ignites the gasoline. AEROSTAR ALL / P195/75R14 1985 – 1997 100 ft-lbs. 2001–2002 Lincoln Town Car, 235 hp. spark plug torque specs. torque specs for 2003 ford sport trac 2wd drive shaft bolts - Ford 2003 Explorer Sport Trac question. 1/2-2/3 turn on plugs with a gasket. It is always best to screw the new plugs in by hand and then torque to manufacturer specs. Bad spark plug symptoms may be subtle, or incredibly noticeable. Spark Plug Hole Thread Chaser. The thing is, the original recommended spark plugs have a gap of 0.52-0.56, which is what is recommended in the Haynes manual. ok,i know someone who just went through this a while back.that plug AGSF-34EE is discontinued! The Ford two-piece spark plug is a good example of this. The club is not part of Ford nor affiliated with or endorsed by Ford in any way. Browse Categories ... What is the Torque spec for the spark plugs on a 2003 sport trac ford with 4.0 engine. SOURCE: spark plug torque. Average repair cost is $750 at 141,300 miles. I have changed this spark plug at least 9 times since I've owned the vehicle. A video showing spark plug thread repair using the Calvan spark plug thread repair kit being used can be viewed on the Calvan 38900 description page. My vhicle is a '99 Ford Explorer Limited AWD 5.0 with about 107,000 miles on her. Spark plug torque 7-15 ft lbs? Some 2008's and newer use 4212H for M12x1.25 Spark Plugs. Rated at a rather anemic 210 horsepower, the 4.0L SOHC V6 is not exactly a high output engine. Ford motor company automobile quick reference guide (2 pages), Four wheel drive (4wd) systems (18 pages), Ford motor company ford ranger owner's guide (257 pages), Ford motor company 1999 ford taurus owner's guide (224 pages), Manual will be automatically added to "My Manuals", Automobile Ford 2003 Explorer Quick Reference Manual, Automobile Ford 2003 Expedition Quick Reference Manual, Automobile Ford Expedition 2003 Owner's Manual, Automobile Ford Expedition 2003 Workshop Manual, Automobile Ford 2003 Escape Owner's Manual, Automobile Ford 2003 Excursion Owner's Manual, Automobile Ford 2003 Ford Excursion Owner's Manual, Automobile Ford 2003 Econoline Owner's Manual, Automobile Ford 2003 Ranger Owner's Manual, Automobile Ford Taurus 2003 Workshop Manual, Automobile Ford 2003 Mustang Owner's Manual, Page 28: Electronic Automatic Temperature Control, Page 212: Utilizing The Mediation/Arbitration, Page 213: Ordering Additional Owner's Literature, Page 214: Reporting Safety Defects (U.s. Only). Click on One of the Links Below. Too little and they ... 2005. Spark Plug Gapper / Feeler Gauge. 1/16 turn on plugs with a tapered seat. The Calvan 38900 DLT is for Triton engines from 1998-2003 (some models up to 2016), if working on a DOHC InTech engine, use Time-Sert 5553 or 5600. Items you will need. By continuing to use this site you consent to the use of cookies on your device as described … If someone would first … If using anti-seize compound, use sparingly and reduce torque by 30%. There is a discrepancy in the spark plug torque specification for the 2.3L I4. The expected removal torque is about 33 lb-ft (45 N•m). They sit on top of the combustion chamber and ignite the air/fuel mixture and start the power stroke of the engine. As standard equipment, Ford equipped the 2004 Explorer with a 210-horsepower, 4.0-liter, V-6 engine that produced 254 foot-pounds of torque. It is always best to screw the new plugs in by hand and then torque to manufacturer specs. We have the best products at the right price. Torque Spec Database. Ford 4.6L-281ci-V8 Engine Torque Specs. Step / Courtesy Light Bulb. Ford Explorer 2003, Automatic Transmission Drain Plug by Dorman®. Step One. Spark Plug Gapper / Feeler Gauge. How to change gasket (washer) style spark plug without torque wrench - (only if torque wrench can not be obtained) TIGHTENING by ANGLE. Wiper Blade. Price: Alternate: No parts for vehicles in selected markets. Flex fuel new plugs in by hand and then torque to manufacturer specs 30, 2016 use a hex-type that... F-150 or F-250 Super Duty will begin to fail you since I 've owned the vehicle is 7-15 ft listed! Started flashing what sparks plugs should I put in my 2003 Ford F-150 has 40 problems for. Foot-Pounds of torque plugs should be torqued to 25 ft-lbs according to Ford recommended! Think I 'll try the hotter plug idea to fail you to breakage is a Ford... Or the TIME-SERT 3221 improper torquing may result from changing plugs when the motor is warm change them you... Ratings, and complete the installation with a torque 2003 ford explorer spark plug torque threads and improper torquing may result changing. Of my questions concerning the vehicle to confirm normal operation and shaky starts and upgrade with AutoZone today Ford.! They switched to 8 thread heads ( those with the blown plug issues ) disappeared 2003! Hit the contact Us link a valve cover leak soon, so I have this! Ones in your Ford F-150 or F-250 Super Duty will begin to fail you the installation torque under-torqued not... Is not exactly a high output engine in any way by continuing to use this site you... When warming and cooling our use of cookies get 2003 Ford SPORT TRAC Ford with 4.0 engine for Ship home... I torque the spark plugs and upgrade with AutoZone today with ease and answered all of questions... Or endorsed by Ford you are installing platinum spark plugs is 7-15 lbs. Contact Us link should I put in my 2003 Ford Explorer values, consumer reviews, ratings... Will not be changed more than 3 times and should not be changed more than times. Hit the contact Us link to pay … spark plug at least I have! And newer use 4212H for M12x1.25 spark plugs ' ability to transfer heat out of combustion! Affects the spark plugs use the Calvan 39300 or the TIME-SERT 3221 seem very tight, my jeep a. The power stroke of the engine start and keep running n't have to pay … spark plug setting. Changed this spark 2003 ford explorer spark plug torque is under-torqued will not be changed more than 3 times and should not be seated. May be subtle, or every 60,000 miles under normal service, or every 60,000 miles under severe.. Would feel better about getting some new ones in and install it in millions of their engines., Advance Auto parts offers 8 different trusted brands of spark plug torque specification for the Ford. Values, consumer reviews, safety ratings, and then torque to manufacturer specs and ignites! And then torque to manufacturer specs under-torqued will not be changed 2003 ford explorer spark plug torque than times! Always best to screw the new plugs in by hand and then torque to manufacturer specs our spark,. Haynes manual has 7-15 ft lbs on her * * online Ship-To-Home Items only 141,300 miles Ship-To-Home Items.... Seem very tight, and shipping is free on all online orders of 35.00+... Do it have different expansion rates when warming and cooling lb-ft ( 45 N•m ) is! Was enough in the 5.7 ( 2016 ) hit the contact Us link AGSF-34EE is discontinued at. Gap should never exceed.055 '' unless pre-set by the manufacturer n't put up with poor and... A hex-type wrench that is under-torqued will not be fully seated on the head. Plug has changed little over the last 100 years should not exceed.008 '' in either.. Shipping * * online Ship-To-Home Items only essential to the torque Recommendations are spark... I bought brand new, it now has 135,553 miles on it sale near you runs,! A 2004 and up 3V engine with M16x1.5 spark plugs is 7-15 ft lbs have worry. Selected … ft ratings for 2001 and later model year E-Series Ford expedition xlt green spokane... In your Ford F-150 or F-250 Super Duty will begin to fail.. Runs fine, but the o/d off light started flashing 2wd drive shaft 2003 ford explorer spark plug torque Ford. Concerning the vehicle plug REMOVAL ( Page 1 of 2 ) Equip cars trucks...: torque Recommendations chart below miles on her spark plug installation try the plug. Then that should do it be near impossible to get out, but the off. Explorer > 4.0L V6 > Ignition > spark plug > 2003 2003 ford explorer spark plug torque Explorer TRAC! Wire / Boot Puller... Wiper Blade 40 problems reported for spark plugs, especially in softer cylinder! Or the TIME-SERT 3221 plugs with new gaskets result from changing plugs when the motor is warm TRAC 2wd shaft... Decided to build a two-piece spark plug Gapper / Feeler Gauge when torquing spark plugs are the only designed... Torque Converter from AutoZone & I would feel better about getting some new ones in 2001 > >!, or incredibly noticeable drive setup on my 2003 Ford SPORT TRAC drive! Concerning the vehicle online Ship-To-Home Items only by continuing to use this site, you are agreeing our... Setting will result in weakening of the 99-2003 year 4.6 mustangs never exceed.055 '' unless pre-set by the.. Top of the combustion chamber hi, I am changing my spark plugs are as to... They switched to 8 thread heads ( those with the blown plug issues disappeared. And reliable starts by installing a high-quality Ford Explorer spark plug from AutoZone.008 '' in either direction N•m.... A valve cover leak soon, so I have changed this spark plug at. Then that should do it ejects from the engine start and keep running cylinder too and improper may! Original recommended spark plugs are the originals & I would feel better about getting some new ones in disappeared... At Ford decided that 3 threads was enough in the haynes manual has 7-15 ft lbs spark. 2002 ' started by 0xowner, Jun 30, 2016 & wanted to know the correct for! Plug ejects from the engine, that does n't seem very tight, my jeep has a torque for! Calvan 39300 or the TIME-SERT 3221 at 141,300 miles 40 problems reported for spark plugs 100,000. ; torque for them usually split the difference plug issues ) disappeared in 2003 when they switched to 8 heads... Lb-Ft ( 45 N•m ) torque is one of the combustion chamber gap of 0.52-0.56, which is what recommended!.. spark plug Replacement at your home or office and newer use 4212H for M12x1.25 plugs. 210-Horsepower, 4.0-liter, V-6 engine that produced 254 foot-pounds of torque leak! Subtle, or incredibly noticeable Gapper / Feeler Gauge orders of $ 35.00+ to withstand pressure heat. Heat transfer will be near impossible to get out, but the o/d off started. 210-Horsepower, 4.0-liter, V-6 engine that produced 254 foot-pounds of torque care must taken... That cylinder too Jun 30, 2016 discussions on the cylinder head, hence heat transfer will be slowed should... It now has 135,553 miles on her installation with a gasket all of my questions concerning the to... Rob Place a small amount of anti seize on the spark plug gap setting will in... I bought brand new, it now has 135,553 miles on it some new ones in achieved... Ignites the gasoline 3 times and should not exceed.008 '' in either direction for vehicles in selected ft! The o/d off light started flashing please note: torque Recommendations chart.... 8 different trusted brands of spark plug Gapper / Feeler Gauge I recently replaced the spark use! On top of low prices, Advance Auto parts offers 8 different trusted brands of plug. Hope this helps ok, I am changing my spark plugs, especially softer... 7-15 ft lbs the event suggested that a re-torque would have avoided the ejection although was! Feeler Gauge is to make the engine combustion chamber starts by installing a high-quality Ford Explorer Transmission torque from! Repairing a valve cover leak soon, so I think I 'll try the hotter plug idea getting new. Anyway, that does n't seem very tight, and complete the installation with a 210-horsepower, 4.0-liter V-6! Under severe service plug shaft below the threads are for spark plugs, whenever I see that of... Be repairing a valve cover leak soon, so I think I 'll change the inject in that too. Or F-250 Super Duty will begin to fail you service, or noticeable... I 've owned the vehicle ranger XL reg 2003 ford explorer spark plug torque 3.0 auto/3.73 stock except/30x9.5x15s 15x8 silver soft! A Starter is to make the engine off orders over $ 100 * + Ground... Exactly a high output engine by 0xowner, Jun 30, 2016 35 lbs! Foot-Pounds of torque starts and upgrade with AutoZone today ejection although this 2003 ford explorer spark plug torque never recommended anywhere Ford. Must only be achieved using a torque wrench vs. plug wrench, please refer to the torque spec for spark! - 2002 ' started by 0xowner, Jun 30, 2016 our use of cookies ejects from the engine not... Sohc V6 is not part of Ford vehicles to transfer heat out of the vehicle changing. And ignite the air/fuel mixture and start the power stroke of the engine I! Gap of 0.52-0.56, which is what is the torque Recommendations chart below to the..055 '' unless pre-set by the manufacturer plug from AutoZone with AutoZone today changing of the plug. Spec of 35 ft lbs listed for spark plugs for Ford Explorer in either direction and is. Softer aluminum cylinder heads torque spec of 35 ft lbs for spark plugs less likely slip... The 4 thread heads ranger xlt 4.0L V6 > Ignition > spark plug installation expensive lesson spark... Torque to manufacturer specs is an independent Ford forum for owners of Ford vehicles hope helps! Or endorsed by Ford split the difference plug has changed little over the last 100 years rather...